考虑测量野值的锂电池异常数据检测与SOC估计算法

doi:10.16180/j.cnki.issn1007-7820.2023.05.006

摘要/Abstract

摘要：

针对锂电池状态估计中传感器测量出现野值的问题,文中设计了卡方检测器和相应的滤波算法,消除了野值对锂电池荷电状态估计的影响。通过二阶RC等效电路对电池动力学模型进行描述,并采用卡尔曼滤波的方法离线辨识电池模型的参数。在考虑了传感器数据存在野值的情况下,采用卡方检测器对野值进行实时检测。当检测到野值发生时,根据零阶保持的思想提出一种只依赖于模型的SOC估计算法,有效地抵抗了测量野值。在FUDS工况下,通过实验仿真发现,文中设计的野值检测器和改进的SOC估计算法能够精确检测到野值的发生,并可保证SOC的估计误差在2%以内,体现了良好的估计性能。

关键词: 锂离子电池, 等效电路模型, 卡尔曼滤波, 参数辨识, 传感器测量野值, 卡方检测, SOC估计, FUDS

Abstract:

In view of the problem of outliers in sensor measurement in lithium battery, a chi-square detector and corresponding filtering algorithm are designed to eliminate the influence of outliers on lithium battery state of charge estimation in this study. The second-order RC equivalent circuit is selected to describe the battery dynamic model, and the parameters of the battery model are identified by Kalman filter in an off-line way. Considering the existence of outliers in sensor data, the chi-square detector is used to detect the outliers in real-time. When outliers are detected, an improved SOC estimation algorithm that only depends on the model is proposed according to the idea of zero-order preservation, which can resist the measured outliers well. Under FUDS condition, the experimental simulation shows that the designed outlier detector and the improved SOC estimation algorithm can accurately detect the occurrence of outliers, and the estimation error of SOC is guaranteed within 2%, reflecting good estimation performance.

Key words: lithium-ion battery, equivalent circuit model, Kalman filter, parameter identification, sensor measurement outlier, chi-square detection, SOC estimation, FUDS

中图分类号:

TP391

王昌松,陈辉,王立成,瞿枫. 考虑测量野值的锂电池异常数据检测与SOC估计算法[J]. 电子科技, 2023, 36(5): 34-40.

WANG Changsong,CHEN Hui,WANG Licheng,QU Feng. Abnormal Data Detection and SOC Estimation Algorithm for Lithium Battery Considering Measured Outliers[J]. Electronic Science and Technology, 2023, 36(5): 34-40.

图/表 11

图1

图2

图3

图4

图5

图6

图7

图8

图9

图10

图11

参考文献 19

[1]	Zhang C B, Zhu Y Y, Dong G Z, et al. Data-driven lithium-ion battery states estimation using neural networks and particle filtering[J]. International Journal of Energy Research, 2019, 43(14):8230-8241.
[2]	Li S X, Hu M H, Li Y X, et al. Fractional-order modeling and SOC estimation of lithium-ion battery considering capacity loss[J]. International Journal of Energy Research, 2019, 43(1):417-429. doi: 10.1002/er.v43.1
[3]	史卫豪, 王顺利, 于春梅, 等. 无人机锂电池电路等效和荷电状态智能计算估计[J]. 自动化仪表, 2020, 41(5):65-70.
	Shi Weihao, Wang Shunli, Yu Chunmei, et al. UAV lithium battery circuit equivalent and state of charge intelligent calculation estimation[J]. Process Automation Instrumentation, 2020, 41(5):65-70.
[4]	Farjah A, Ghanbari T. Early ageing detection of battery cells in battery management system[J]. Electronics Letters, 2020, 56(12):616-619. doi: 10.1049/ell2.v56.12
[5]	张正杨, 刘方. 一种基于CAN总线的电动车电池管理系统[J]. 电子科技, 2014, 27(3):129-132.
	Zhang Zhengyang, Liu Fang. A battery management system of electrical vehicle based on CAN bus[J]. Electronic Science and Technology, 2014, 27(3):129-132.
[6]	周娟, 孙啸, 刘凯, 等. 联合扩展卡尔曼滤波的滑模观测器SOC估算算法研究[J]. 中国电机工程学报, 2021, 41(2):692-703.
	Zhou Juan, Sun Xiao, Liu Kai, et al. Research on the SOC estimation algorithm of combining sliding mode observer with extended Kalman filter[J]. Proceedings of the CSEE, 2021, 41(2):692-703.
[7]	Xu Y D, Hu M H, Fu C Y, et al. State of charge estimation for lithium-ion batteries based on temperature-dependent second-order RC model[J]. Electronics, 2019, 8(9):1012-1031. doi: 10.3390/electronics8091012
[8]	Liu S, Wei G L, Song Y, et al. Extended Kalman filtering for stochastic nonlinear systems with randomly occurring cyber attacks[J]. Neurocomputering, 2016, 207(26):708-716.
[9]	Zhou L, Wang Z D, Geng H, et al. Set-membership filtering subject to impulsive measurement outliers: A recursive algorithm[J]. IEEE-CAA Journal of Automatica Sinica, 2021, 8(2):377-388.
[10]	Ma L F, Wang Z D, Hu J, et al. Probablity-guaranteed envelope-constrained filtering for nonlinear systems subject to measurement outliers[J]. IEEE Transactions on Automatic Control, 2021, 66(7):3274-3281. doi: 10.1109/TAC.2020.3016767
[11]	Yan R Y, He X, Wang Z D, et al. Detection, isolation and diagnosability analysis of intermittent faults in stochastic systems[J]. International Journal of Control, 2018, 91(2):480-494. doi: 10.1080/00207179.2017.1286039
[12]	Luo Y Q, Wang Z D, Wei G L, et al. Fault detection for fuzzy systems with multiplicative noises under periodic communication protocols[J]. IEEE Transactions on Fuzzy Systems, 2018, 26(4):2384-2395. doi: 10.1109/TFUZZ.2017.2774193
[13]	Mu H L, Cheng Y M, Gou B, et al. Method of joint fault detection based on evidential reasoning[J]. Control and Decision, 2016, 31(9):1589-1593.
[14]	蒋芹, 张轩雄. 电动汽车锂离子电池模型参数辨识和荷电状态估算[J]. 电子科技, 2020, 33(2):32-36.
	Jiang Qin, Zhang Xuanxiong. Parameter identification and state of charge estimation of lithium ion battery model for electric vehicles[J]. Electronic Science and Technology, 2020, 33(2):32-36.
[15]	Ali K, Tahir M. Maximum likelihood-based robust state estimation over a horizon length during measurement outliers[J]. Transactions of the Institute of Measurement and Control, 2020, 43(3):510-518. doi: 10.1177/0142331220928896
[16]	Liu S, Wang Z D, Chen Y, et al. Protocol-based unscented Kalman filtering in the presence of stochastic uncertainties[J]. IEEE Transactions on Automatic Control, 2020, 65(3):1303-1309. doi: 10.1109/TAC.9
[17]	段瑞林, 王奔, 魏久林, 等. 基于自适应卡尔曼滤波的磷酸铁锂电池荷电状态估计[J]. 电工技术, 2019(19):7-10.
	Duan Ruilin, Wang Ben, Wei Jiulin, et al. State of charge estimation for the LiFePO₄ battery based on adaptive extended Kalman filter algorithm[J]. Electric Engineering, 2019(19):7-10.
[18]	张维, 步兵, 王洪伟. 基于KF的列控系统数据篡改攻击检测方法[J]. 中国安全科学学报, 2019, 29(S1):32-37. doi: 10.16265/j.cnki.issn1003-3033.2019.S1.007
	Zhang Wei, Bu Bing, Wang Hongwei. An intrusion detection method of data tampering attack in train control system based on KF[J]. China Safety Science Journal, 2019, 29(S1):32-37. doi: 10.16265/j.cnki.issn1003-3033.2019.S1.007
[19]	Liu Z, Dang X J, Jing B Q, et al. An improved model for parameters identification of lithium-ion battery based on dual Kalman filter[J]. Journal of Applied Science and Engineering, 2019, 22(4):607-615.