容错控制下电磁轴承磁极故障磁场解析

doi:10.16180/j.cnki.issn1007-7820.2021.11.013

摘要/Abstract

摘要：

容错控制下电磁轴承出现磁极故障时,磁极间的磁耦合以及电磁力的非线性使得磁极面上无法产生需要的电磁力,会给转子的悬浮带来较大影响。针对这一问题,文中使用有限元软件仿真分析了强耦合和弱耦合结构电磁轴承出现单个和两个磁极故障时的磁场分布情况,并从磁场的角度对比分析了这两种结构对转子悬浮的影响。针对8极径向电磁轴承两个磁极间隙中存在较多的漏磁,而电磁轴承一般只能控制磁极端面上的磁通这一问题,文中对不同磁极数量的强耦合结构电磁轴承在定转子间气隙的磁通密度进行仿真分析。结果表明,12极电磁轴承的电流利用率超过99%,有效减少了电磁轴承的漏磁。

关键词: 电磁轴承, 容错控制, 磁极故障, 磁场, 拓扑结构, 仿真分析

Abstract:

When an AMB has a magnetic pole failure under fault-tolerant control, the magnetic coupling between the magnetic poles and the nonlinearity of the electromagnetic force make it impossible to generate the required electromagnetic force on the magnetic pole surface, which will has a greater impact on the suspension of the rotor. To solve this problem, in this study, finite element software is used to simulate and analyze the magnetic field distribution of the AMB with strong coupling and weak coupling structure when single and two magnetic pole failures occur, and the influence of these two structures on the suspension of the rotor is compared and analyzed from the perspective of the magnetic field. In view of the fact that there is more magnetic flux leakage in the gap between the two magnetic poles of 8-pole radial AMB, the AMB generally can only control the magnetic flux on the magnetic poles, the magnetic flux density of the air gap between the rotors is simulated and analyzed. The simulation results show that the current utilization rate of the 12-pole AMB exceeds 99%, which effectively reduces the magnetic flux leakage.

Key words: active magnetic bearing, fault-tolerant, pole failure, magnetic field, topology, simulation analysis

中图分类号:

TN99

王佳良,蒋科坚,朱芳甫. 容错控制下电磁轴承磁极故障磁场解析[J]. 电子科技, 2021, 34(11): 81-87.

WANG Jialiang,JIANG Kejian,ZHU Fangfu. Magnetic Field Analysis of Magnetic Bearing Pole Fault under Fault-Tolerant Control[J]. Electronic Science and Technology, 2021, 34(11): 81-87.

图/表 9

图1

图2

图3

图4

图5

图6

图7

图8

表1

参考文献 18

[1]	石庆才, 谢振宇, 吴凯锋, 等. 同极型和异极型磁轴承的磁场分布和功率损耗分析[J]. 机械设计, 2011, 28(11):22-27.
	Shi Qingcai, Xie Zhenyu, Wu Kaifeng, et al. Analysis on electromagnetic field and power loss of homo-polar and heteropolar magnetic bearing[J]. Journal of Mechanical Design, 2011, 28(11):22-27.
[2]	田录林, 吴少华, 田亚琦. 矩形截面永磁环构成的Halbach永磁轴承结构优化[J]. 电网与清洁能源, 2017, 33(11):70-75.
	Tian Lulin, Wu Shaohua, Tian Yaqi. Structure optimization of Halbach permanent magnetic bearing constituted by rectangular section permanent magnetic rings[J]. Power System and Clean Energy, 2017, 33(11):70-75.
[3]	楼英邦, 张小玉, 方玺, 等. 径向磁力轴承多因素耦合研究[J]. 轴承, 2018(10):18-23.
	Lou Yingbang, Zhang Xiaoyu, Fang Xi, et al. Research on multi-factor coupling of radial magnetic bearings[J]. Bearing, 2018(10):18-23.
[4]	白文鑫, 刘文韬. 基于遗传算法的零偏置磁轴承定子结构优化[J]. 机械工程与自动化, 2019(4):31-34.
	Bai Wenxin, Liu Wentao. Structure optimization of zero bias magnetic bearing stator based on genetic algorithm[J]. Mechanical Engineering and Automation, 2019(4):31-34.
[5]	Maslen E H, Meeker D C. Fault tolerance of magnetic bearings by generalized bias current linearization[J]. IEEE Transactions on Magnetics, 1995, 31(3):2304-2314. doi: 10.1109/20.376229
[6]	胡俊, 胡业发, 程鑫, 等. 基于小波变换的磁悬浮轴承冗余位移传感器故障诊断方法[J]. 制造业自动化, 2017, 39(4):79-83.
	Hu Jun, Hu Yefa, Cheng Xin, et al. Fault diagnosis of redundant displacement sensor for magnetic bearings based on wavelet transform[J]. Manufacturing Automation, 2017, 39(4):79-83.
[7]	宗鸣, 冯超, 郑安琪. 基于FPGA自适应滤波器的磁轴承位移传感器故障信号处理分析[J]. 电气工程学报, 2018, 13(8):1-6.
	Zong Ming, Feng Chao, Zheng Anqi. Fault analysis of magnetic bearing displacement sensor based on FPGA adaptive filter[J]. Journal of Electrical Engineering, 2018, 13(8):1-6.
[8]	郑安琪. 主动磁悬浮轴承传感器故障识别与监测系统研究[D]. 沈阳:沈阳工业大学, 2018.
	Zhen Anqi. Research on active magnetic bearing sensor fault identification and monitoring system[D]. Shenyang:Shenyang University of Technology, 2018.
[9]	纪历, 徐龙祥, 唐文斌. 磁悬浮轴承数字控制器故障诊断与处理[J]. 中国机械工程, 2010, 21(3):289-295.
	Ji Li, Xu Longxiang, Tang Wenbin. Fault diagnosis and treatment for AMB digital controller[J]. The Chinese Mechanical Engineering, 2010, 21(3):289-295.
[10]	程鑫, 刘晗, 王博, 等. 基于双核处理器的主动磁悬浮轴承容错控制架构[J]. 山东大学学报(工学版), 2018, 48(2):72-80.
	Cheng Xin, Liu Han, Wang Bo, et al. A fault-tolerant control architecture for active magnetic bearing based on dual core processor[J]. Journal of Shandong University (Engineering Science), 2018, 48(2):72-80.
[11]	Won J S, Na U J. Design of flux invariant, fault tolerant homopolar magnetic bearings[C]. Busan:Proceeding of the SICE-ICASE International Joint Conference, 2006.
[12]	崔东辉, 徐龙祥. 基于坐标变换的径向主动磁轴承容错控制[J]. 控制与决策, 2010, 25(9):1420-1425.
	Cui Donghui, Xu Longxiang. Fault tolerant control of radial active magnetic bearing based on coordinate transformation[J]. Control and Decision, 2010, 25(9):1420-1425.
[13]	段焱, 郑世强. 电磁轴承五种故障模式下的容错控制与分析[J]. 制造业自动化, 2013, 35(1):100-103.
	Duan Yan, Zheng Shiqiang. Fault-tolerant control and analysis for electromagnetic bearing in five kinds of failure modes[J]. Manufacturing Automation, 2013, 35(1):100-103.
[14]	魏彤, 刘云波. 基于反馈线性化和保性能控制的轴向磁轴承单侧线圈故障容错控制[J]. 光学精密工程, 2014, 22(3):695-703.
	Wei Tong, Liu Yunbo. Single coil fault-tolerant control for axial magnetic bearing based on feedback linearization and guaranteed cost control[J]. Optical and Precision Engineering, 2014, 22(3):695-703.
[15]	耿青玲, 张黎. 电流再分配方法在弱耦合径向磁力轴承执行器容错控制中的应用[J]. 机械工程师, 2016(6):105-108.
	Geng Qingling, Zhang Li. Application of current distribution method on fault tolerant control of weakly-coupled radial magnetic bearing actuator[J]. Mechanical Engineer, 2016(6):105-108.
[16]	Cheng X, Cheng Q, Zeng H Y, et al. Reconfiguration rules for loosely-coupled redundant supporting structure in radial magnetic bearings[J]. International Journal of Applied Electromagnetics & Mechanics, 2016, 51(2):91-106.
[17]	Cheng X, Liu H, Song S, et al. Reconfiguration of tightly-coupled redundant supporting structure in active magnetic bearings under the failures of electromagnetic actuators[J]. International Journal of Applied Electromagnetics & Mechanics, 2017, 54(3):421-432.
[18]	陈善章, 张振东. 基于Ansoft汽车永磁电机磁场有限元分析[J]. 电子科技, 2016, 29(3):168-171.
	Chen Shanzhang, Zhang Zhendong. Finite element analysis of EM field of vehicle drive motor based on Ansoft[J]. Electronic Science and Technology, 2016, 29(3):168-171.

磁极数量	磁通密度/mT	电流利用率/%
4极	301.865	97.21
6极	304.272	97.99
8极	305.712	98.45
10极	307.158	98.92
12极	308.326	99.29
14极	308.878	99.47